Warning horn going off
Moderators: Redneck_Randy, badmoonrising, lakerunner
- mitchwilldoit
- Posts: 24
- Joined: Tue Dec 17, 2013 4:31 pm
- Location: Weeki Wachee florida
Warning horn going off
I have a mid 90' merc 50 4 stroke Lately the little horn connected to the console has been sounding. so far at slow speed. I turn the engine off restart runs quiet then noise. Lots of water out of the engine I haven't connected the temp gauge yet All else sound good Thoughts ???
- lakerunner
- Site Moderator
- Posts: 4820
- Joined: Fri Mar 17, 2006 2:31 pm
- Location: Live in McAlester, Ok Boat on Tenkiller
- Contact:
Re: Warning horn going off
Time for new impeller. Flush system also.
Loyd & Betty Meeks
Livin the lake life
2004 Tracker 22 Regency/2010 90 E-Tec. Pulled by Ford 2020 F 250,
McAlester, Oklahoma
Home lake is Tenkiller
Livin the lake life
2004 Tracker 22 Regency/2010 90 E-Tec. Pulled by Ford 2020 F 250,
McAlester, Oklahoma
Home lake is Tenkiller
Re: Warning horn going off
The impeller will probably fix it. If not the thermostat and poppit valve may need to be replaced. I had an alarm earlier this year on low to mid rpms and it was after I had replaced the impeller a couple months earlier. Changing the thermostats and poppit fixed it.
- mitchwilldoit
- Posts: 24
- Joined: Tue Dec 17, 2013 4:31 pm
- Location: Weeki Wachee florida
Re: Warning horn going off
Thanks !! but what's a poppit ?
- chopper6358
- Posts: 94
- Joined: Thu May 22, 2014 3:23 pm
- Location: paducah ky
Re: Warning horn going off
The poppet valve regulates water pressure in the block. At idle your water pump barely pushes water through the block, especially through the top cylinders. When you increase rpm's the water is forced through the motor by a combination of the water pump and the force of the water pushing into your water pump from forward motion in the boat. The poppet valve will open when the water pressure in the block becomes too high and it relieves the motor of this extra water pressure by redirecting the water out the exhaust ports. If the valve is too weak or has a leak it let's water pass that is needed in the upper parts of the block.
1998 Crest 25' Tritoon,115 Johnson 2 stroke. 13x11 4 blade spitfire prop, pulled with 2007 GMC sierra classic 2500hd 4x4. ky lake :nutkick :thumbsup :eviltaunt
Re: Warning horn going off
Also possibly low oil pressure alarm. Change your filter recently?
ToddBob
'Al the Mirthmaker' (The Third)
Build-- viewtopic.php?f=16&t=14007
Rainy Lake/Voyageurs National Park
International Falls, MN
'Al the Mirthmaker' (The Third)
Build-- viewtopic.php?f=16&t=14007
Rainy Lake/Voyageurs National Park
International Falls, MN
- mitchwilldoit
- Posts: 24
- Joined: Tue Dec 17, 2013 4:31 pm
- Location: Weeki Wachee florida
Re: Warning horn going off
Is the poppit easily changeable and where is it. I did an oil and filter change when I redid the bottom paint a few months ago.
Re: Warning horn going off
On my motor (yamaha) it was easy. It took me 30 minutes to change the poppet and both thermostats with the boat still in the water.